United States Stove 2000 Spezifikationen PDF herunterladen (Seite 19)

3-90-08691R17_11/13

Chimney System

Installing to a Prefabricated Chimney

WhenventingyourTLC2000usingaprefabricatedchimney,

be sure to contact local building code authorities, and to

follow the manufacturer’s instructions exactly. Use only

themanufacturer’sparts;donotusemakeshiftinstallation

techniques.Allprefabricated chimneysmustbetested to

eithertheU.S.orCanadianhigh-temperaturestandards,UL

103orULC-629.

DO NOT CONNECT THIS UNIT TO A CHIMNEY FLUE

SERVING ANOTHER APPLIANCE.

Existing Masonry Chimneys

Ifyouplanonusingapre-existingmasonrychimney,have

itthoroughlyinspectedandcleaned.Anyfaultswhichmake

thechimneyunsafeandunusablemustberepairedpriorto

use.Thesecanincludeimproperheight,structuraldefects,

blockages,inadequateclearancetocombustibles,unsealed

openingsintootherroomsofthehouse,signsofcreosoteor

smokeleakage,alooseorabsentclean-outdoor,orabsence

ofaliner.

DO NOT CONNECT TO ANY AIR DISTRIBUTION DUCT

OR SYSTEM

Venting to a Masonry Chimney

Whenconnectingtoamasonrychimney,severalprovisions

arestandard.First,whetherthechimneyconnectorisvented

tothechimneythroughathimbleorabreechpipe,neither

must pass beyond the inner surface of the chimney liner,

andbothmustbermlycementedinplacewithrefractory

cement. (A thimble is a masonry pipe which is inserted

through the chimney wall, and is frequently the preferred

method;abreechpipeisapieceofsteelpipeusedthesame

way.)InCanada,abreechpipehasridgesorprotrusionsto

lockitrmlyintotherefractorycement.Ineithercase,the

chimneyconnectorventstothechimneythroughthethimble

orbreechpipe.

Usingathimble,theconnectorslidescompletelyinsidethe

masonrytotheinneredgeoftheueliner,andmaybeeasily

removed for chimney and connector inspection.A breech

pipemustextendatleast2"(50mm)intotheroom,sothe

connectorcanbeattachedwithsheetmetalscrews.

Venting to a Masonry Fireplace Chimney

Insomesituations,acodecompliantchimneyoriginallyused

for a masonry replace may be used to install your TLC

2000.Inadditiontotherequirementsfoundintheprevious

paragraphs,itisimportanttobeawarethatallclearances

mustbemet,includingthosefromthechimneyconnectorto

combustibles—18"(360mm)tosidesand18"(450mm)

toceiling. Donot forgetto includeoor protectionin your

plans.(SeeClearancesandFloorProtectioninthissection.)

Sincemanyreplaceshaveexposedwoodenmantelsand

trim,pay special attention tothe clearances necessary to

thesematerials.

Ifyourreplacechimneyisbehindacombustiblewall,you

must use an approved wall pass-through system to gain

access to the masonry chimney. The chimney connector

must enter the chimney at a place where it is lined, and

thereplacemustbe made inoperable.Forexample,you

mightremovethedamper,replacingitwithasecure,airtight,

noncombustible seal (removable for inspection); this also

satisestherequirementthatnoroomairmustbeallowed

toenterthechimney.

TheHarmanTLC2000wastestedwiththefueldooropen

andclosed.

If you operate with the door open, be sure to install the

optionalrescreen,andbesurethecleanoutcoverabove

thereboxisremoved.

Do not burn any fuel other than those specied. Other

solidfuels,suchascharcoal,cancauseincreasedcarbon

monoxideproductionoroverring.Neverusehighlyvolatile

substances in your stove, such as gasoline, which could

causeanexplosion.

When solid fuels are burned completely, they produce

waterandcarbondioxide.However,inlongslowburns,a

substantialamountofcarbonmonoxidemaybeproduced.

Ifallowedtobuildup,carbonmonoxide(whichisodorless)

canprovefatallypoisonous.Properventilationanddraftwill

prevent this from happening. If you smell smoke, turn up

the air control lever setting, and thoroughly ventilate your

dwelling. During future burns, be careful not to overload

thestovewithfuel,soyouwillnotbetemptedtoconstantly

operateatalowaircontrolsetting.

Othercausesofpoorventilationordraftareicing,exhaust

fans,ablockedoutsideairinlet,androomairstarvation.If

yourstoveissluggishandyougetoccasionalodor,check

thesepossibilitiesandincreasetheairowinyourhome.

WARNING

DO NOT INSTALL IN SLEEPING ROOM.

Chimney

Connector

Clay thimble, reaching

just to the inside of the

chimney liner

Mechanical fasteners

(minimum 3) but not at the

bottom of the connector

Chimney liner

inner edges

High-temperature

sealant used to cement

the clay thimble

1 2 ... 14 15 16 17 18 19 20 21 22 23 24 25 26

Kommentare zu diesen Handbüchern

Keine Kommentare

United States Stove 2000 Spezifikationen Seite 19

Kommentare zu diesen Handbüchern

Verwandte Produkte und Handbücher für Öfen United States Stove 2000